Effect of Wet Litter Biochar, Probiotic and Zeolite on Performance, immunity and Small Meat Quality of Broiler Chickens Reared under Cold Stress

Document Type : Research Articles

Authors

• Shokufe Hasanvand ¹
• Ali Khatibjoo ¹
• Hassan Shirzadi ¹
• Yahya Mohammadi ¹
• Mohammad Amir Karimi Torshizi ²
• Derakhshandeh Rahimi ³

¹ Department of Animal Science, Faculty of Agriculture, Ilam University, Ilam, Iran

² Associate Prof. of poultry nutrition, Department of Animal Science, Faculty of Agriculture, Tarbiat Modarres University, Tehran- Iran

³ Assistant Professor, Animal Science Research Department, Ilam Agriculture and Natural Resources Research and Education Center,

10.22067/ijasr.2023.81245.1130

Abstract

Introduction: During the winter months in most parts of Iran, the external temperature often drops below 0 °C. Typically, these temperatures fall below the optimal conditions for chick growth, resulting in cold stress and potential diseases. This can subsequently impact meat quality negatively and reduce breeding efficiency. The environmental temperature beyond the upper and lower limit of the thermoneutral zone is supposed to produce heat or cold stress in animals (Meltzer, 1983). The adverse climatic condition produces physiological stress which has profound economic influence on the productive efficiency including health and disease resistant capacity (Phuong et al., 2016). Exposure of poultry birds to extreme temperature stressor modulates the immune responsiveness and hematic-biochemical parameters of birds (Hangalapura et al., 2004). Among all the environmental stressors, cold stress induces physiological responses which are of high priority and energy demanding for homeotherms. Cold temperature can increase ascites susceptibility by increasing both metabolic oxygen requirements and pulmonary hypertension (Stolz et al., 1992). The biggest obstacle in raising broilers at high altitudes and cold conditions is the ascites syndrome. This condition can be characterized by an accumulation of fluid in the abdominal cavity and elevated mortality that tends to peak between 4-6 weeks of age (James, 2005). The International Biochar Initiative (2017) defines biochar as, “Solid material obtained from thermochemical conversion of biomass in an oxygenlimited environment.” Biochar is an ash substance that is produced from the burning of biological material via pyrolysis. This process heats the biological material in an anaerobic environment causing it to decompose into an ash form. Growth promotion and therapeutic antibiotics have been used to compensate for the high levels of stress, including cold stress,that can be present in intensive animal production. Stress can lower resistance to many of the microorganisms present in the environment; however, stress in general has been reported to have variable effects on the immune system and can both enhance and suppress responses (Siegel, 1995); cold stress has been shown to both stimulate and suppress chickens’ immune response (Regnier and Kelley, 1981; Hangalapura et al., 2006). Probiotics contain live microorganisms and spores which when administered in adequate amount, confer health benefits to the host. Bacillus subtilis (B. Subtilis) and Bacillus licheniformis (B. Licheniformis) are the two most widely used strains of probiotic bacteria in animal diets. Oral administration of B. Subtilis and B. Licheniformis can have a myriad of beneficial effects, such as improved growth and meat characteristics, optimized composition of intestinal microbiota, prevention of some diarrheal diseases, and reduced stresses. For such benefits, B. Subtilis and B. Licheniformis have attracted considerable attention as a potentially beneficial dietary supplement for animal health.  For the many negative effects of antibiotic drugs used in chick production, we want to compare the positive effects of some additives on performance of cold-stressed broiler chickens.
Materials and Methods: In this experiment, in order to examine the effect of solid waste biochar, probiotic and zeolite on improvement of performance, blood indices and small intestine morphology of broiler chickens reared under cold stress, in a completely randomized design, 315 Ross-308 broiler chickens (as hatched) were allocated to 7 treatments, 5 replicates and 9 birds in each in cold and warm houses. Treatments are including: 1) positive control (basal diet in recommended temperature), 2) negative control (basal diet + cold stress), 3-7) negative control + %0.5, %0.75 and 1% solid waste biochar, 0.02% probiotic Ecobacto-P and 1% zeolite, respectively. In cold stress groups, house temperature decreased to 17° C from 7d until end of the experiment (42d).
Results and Discussion: As compared to group reared in warm house, cold stress significantly decreased broiler chickens daily FI and BWG, serum total protein, albumin and globulin concentrations, thymus relative weight, lymphocyte percentage, breast and thigh meat pH, breast meat redness (b) and thigh meat yellowness (a) while increased total and ascitic mortality, red and white blood cell count, blood hemoglobin, heterophile percentage and heterophil to lymphocyte ratio, antibody titter against SRBC, breast and thigh meat whiteness and breast meat MDA concentration (P < 0.05).
Conclusion: In order to orthogonal contrast analysis between negative control group and additive groups, solid waste biochar, probiotic or zeolite couldn’t improve broiler chicken’s growth performance, breast and thigh meat quality parameters, blood metabolites concentration and cell count and did not ameliorate negative effects of cold stress.

Keywords

• Broiler Chicken
• Cold Stress
• Immune Response
• Meat Quality
• Performance
• Probiotic
• Solid Waste Biochar

Main Subjects

• Poultry Nutrition

---

References

1. Adjei, A. A., Matsumoto, Y., Oku, T., Hiroi, Y., & Yamamoto, S. (1994). Dietary agrinine and glutamine combination improves survival in septic mice. Nutrition Research, 14(10), 1591-1599.
2. Adzitey, F., & Nurul, H. (2011). Pale soft exudative (PSE) and dark firm dry (DFD) meats: causes and measures to reduce these incidences-a mini review. International Food Research Journal, 18(1).
3. Aksu, M. I., Karaoǧlu, M., Esenbuǧa, N., Kaya, M., Macit, M., & Ockerman, H. W. (2005). Effect of a dietary probiotic on some quality characteristics of raw broiler drumsticks and breast meat. Journal of Muscle Foods, 16(4), 306-317. https://doi.org/10.1111/j.1745-4573.2005.00023.x
4. Amoah, K., Dong, X.-h., Tan, B.-p., Zhang, S., Kuebutornye, F. K., Chi, S.-y., Yang, Q.-h., Liu, H.-y., Zhang, H.-t., & Yang, Y.-z. (2021). In vitro assessment of the safety and potential probiotic characteristics of three Bacillus strains isolated from the intestine of hybrid grouper (Epinephelus fuscoguttatus♀× Epinephelus lanceolatus♂). Frontiers in Veterinary Science, 426. https://doi.org/10.3389/fvets.2021.675962
5. ARDCorp, B. (2014). Investigating Benefits of Supplementing Broiler Feed with Broiler Litter Biochar.
6. Azargohar, R., & Dalai, A. (2006). Biochar as a precursor of activated carbon. Twenty-seventh symposium on biotechnology for fuels and chemicals. https://doi.org/10.1007/978-1-59745-268-7_62
7. Barbut, S., Zhang, L., & Marcone, M. (2005). Effects of pale, normal, and dark chicken breast meat on microstructure, extractable proteins, and cooking of marinated fillets. Poultry Science, 84(5), 797-802. https://doi.org/10.1093/ps/84.5.797
8. Biesek, J., Kuźniacka, J., Banaszak, M., Maiorano, G., Grabowicz, M., & Adamski, M. (2020). The effect of various protein sources in goose diets on meat quality, fatty acid composition, and cholesterol and collagen content in breast muscles. Poultry Science, 99(11), 6278-6286. https://doi.org/10.1016/j.psj.2020.08.074
9. Blahova, J., Dobšíková, R., Strakova, E., & Suchý, P. (2007). Effect of low environmental temperature on performance and blood system in broiler chickens (Gallus domesticus). Acta Veterinaria Brno, 76(8), 17-23. https://doi.org/10.2754/avb200776S8S017
10. Cheema, M., Qureshi, M., & Havenstein, G. (2003). A comparison of the immune response of a 2001 commercial broiler with a 1957 randombred broiler strain when fed representative 1957 and 2001 broiler diets. Poultry Science, 82(10), 1519-1529.
11. Cheron, B. M. (2017). Evaluation of Biochar as a Feed Additive in Commercial Broiler Diets.
12. Dabbert, C., Lochmiller, R. L., & Teeter, R. G. (1997). Effects of acute thermal stress on the immune system of the Northern Bobwhite (Colinus virginianus). The Auk, 114(1), 103-109. https://doi.org/10.2307/4089069
13. Dadgar, S., Lee, E., Leer, T., Crowe, T., Classen, H., & Shand, P. (2011). Effect of acute cold exposure, age, sex, and lairage on broiler breast meat quality. Poultry Science, 90(2), 444-457. https://doi.org/10.3382/ps.2010-00840
14. Dim, C., Akuru, E., Egom, M., Nnajiofor, N., Ossai, O., Ukaigwe, C., & Onyimonyi, A. (2018). Effect of dietary inclusion of biochar on growth performance, haematology and serum lipid profile of broiler birds. Agro-Science, 17(2), 9-17.
15. Evans, A., Boney, J., & Moritz, J. (2017). The effect of poultry litter biochar on pellet quality, one to 21 d broiler performance, digesta viscosity, bone mineralization, and apparent ileal amino acid digestibility. Journal of Applied Poultry Research, 26(1), 89-98. https://doi.org/10.3382/japr/pfw049
16. Farhadi, D., Shariatmadari, F., & Karimi Torshiz, A. (2013). The Effect of Litter Chemical Additives on Performance, Immune System and Incidence of Ascites Syndrome in Broiler Chickens. Research On Animal Production (Scientific and Research), 3(6), 1-14 (In persian).
17. Ferket, P. R., & Gernat, A. G. (2006). Factors that affect feed intake of meat birds: A review. International Journal of Poultry Science, 5(10), 905-911.
18. Gerlach, H., & Schmidt, H.-P. (2012). Biochar in poultry farming. Ithaka Journal, 2012(1), 262-264p.
19. Haman, F., Péronnet, F., Kenny, G. P., Massicotte, D., Lavoie, C., & Weber, J. M. (2005). Partitioning oxidative fuels during cold exposure in humans: muscle glycogen becomes dominant as shivering intensifies. The Journal of Physiology, 566(1), 247-256. https://doi.org/10.1113/jphysiol.2005.086272
20. Hangalapura, B. (2006). Cold stress and immunity: do chickens adapt to cold by trading-off immunity for thermoregulation? Wageningen University and Research.
21. Hangalapura, B. N., Kaiser, M. G., van der Poel, J. J., Parmentier, H. K., & Lamont, S. J. (2006). Cold stress equally enhances in vivo pro-inflammatory cytokine gene expression in chicken lines divergently selected for antibody responses. Developmental & Comparative Immunology, 30(5), 503-511. https://doi.org/10.1016/j.dci.2005.07.001
22. Hester, P. Y., Muir, W., Craig, J., & Albright, J. (1996). Group selection for adaptation to multiple-hen cages: production traits during heat and cold exposures. Poultry Science, 75(11), 1308-1314. https://doi.org/10.3382/ps.0751308
23. Homma, H., & Shinohara, T. (2004). Effects of probiotic Bacillus cereus toyoi on abdominal fat accumulation in the Japanese quail (Coturnix japonica). Animal Science Journal, 75(1), 37-41. https://doi.org/10.1111/j.1740-0929.2004.00152.x
24. Huff, G., Huff, W., Rath, N., de Los Santos, F. S., Farnell, M., & Donoghue, A. (2007). Influence of hen age on the response of turkey poults to cold stress, Escherichia coli challenge, and treatment with a yeast extract antibiotic alternative. Poultry Science, 86(4), 636-642. https://doi.org/10.1093/ps/86.4.636
25. Huff, G., Huff, W., Rath, N., El-Gohary, F., Zhou, Z., & Shini, S. (2015). Efficacy of a novel prebiotic and a commercial probiotic in reducing mortality and production losses due to cold stress and Escherichia coli challenge of broiler chicks. Poultry Science, 94(5), 918-926. https://doi.org/10.3382/ps/pev068
26. Ivanovic, S., Pisinov, B., Maslic-Strizak, D., Savic, B., & Stojanovic, Z. (2012). Influence of probiotics on quality of chicken meat. African Journal of Agricultural Research, 7(14), 2191-2196.
27. Joseph, S. D., Camps-Arbestain, M., Lin, Y., Munroe, P., Chia, C., Hook, J., Van Zwieten, L., Kimber, S., Cowie, A., & Singh, B. (2010). An investigation into the reactions of biochar in soil. Soil Research, 48(7), 501-515. https://doi.org/10.1071/SR10009
28. Kim, H.-S., Kim, K.-R., Kim, H.-J., Yoon, J.-H., Yang, J. E., Ok, Y. S., Owens, G., & Kim, K.-H. (2015). Effect of biochar on heavy metal immobilization and uptake by lettuce (Lactuca sativa L.) in agricultural soil. Environmental Earth Sciences, 74(2), 1249-1259. https://doi.org/10.1007/s12665-015-4116-1
29. KOT, E., Furmanov, S., & Bezkorovainy, A. (1995). Accumulation of iron in lactic acid bacteria and bifidobacteria. Journal of Food Science, 60(3), 547-550. https://doi.org/10.1111/j.1365-2621.1995.tb09823.x
30. Lehmann, J., Rillig, M. C., Thies, J., Masiello, C. A., Hockaday, W. C., & Crowley, D. (2011). Biochar effects on soil biota–a review. Soil Biology and Biochemistry, 43(9), 1812-1836. https://doi.org/10.1016/j.soilbio.2011.04.022
31. Leishman, E. M., Ellis, J., van Staaveren, N., Barbut, S., Vanderhout, R. J., Osborne, V. R., Wood, B. J., Harlander-Matauschek, A., & Baes, C. F. (2021). Meta-analysis to predict the effects of temperature stress on meat quality of poultry. Poultry Science, 100(11), 101471. https://doi.org/10.1016/j.psj.2021.101471
32. Lin, M. Y., & Chang, F. J. (2000). Antioxidative effect of intestinal bacteria Bifidobacterium longum ATCC 15708 and Lactobacillus acidophilus ATCC 4356. Digestive Diseases and Sciences, 45(8), 1617-1622. https://doi.org/10.1023/A:1005577330695
33. Lin, M. Y., & Yen, C. L. (1999). Inhibition of lipid peroxidation by Lactobacillus acidophilus and Bifidobacterium longum. Journal of Agricultural and Food Chemistry, 47(9), 3661-3664. https://doi.org/10.1021/jf981235l
34. Lotfollahian, H., Shariatmadari, F., Shivazad, M., & Mirhadi, S. (2004). Study on the effects of two kinds of natural zeolite in diets on blood biochemical parameters, relative weight of body organs and broilers performance. Pazhoohesh and sazandegi, 3(17), 18-34 (in persian).
35. Mabe, L. T., Su, S., Tang, D., Zhu, W., Wang, S., & Dong, Z. (2018). The effect of dietary bamboo charcoal supplementation on growth and serum biochemical parameters of juvenile common carp (Cyprinus carpio L.). Aquaculture Research, 49(3), 1142-1152. https://doi.org/10.1111/are.13564
36. Mahajan, P., Sahoo, J., & Panda, P. (2000). Effect of probiotic (Lacto-Sacc) feeding, packaging methods and seasons on the microbial and organoleptic qualities of chicken meat balls during refrigerated storage. Journal of Food Science and Technology (Mysore), 37(1), 67-71.
37. Man, K. Y., Chow, K. L., Man, Y. B., Mo, W. Y., & Wong, M. H. (2021). Use of biochar as feed supplements for animal farming. Critical Reviews in Environmental Science and Technology, 51(2), 187-217. https://doi.org/10.1080/10643389.2020.1721980
38. Meier, S., Borie, F., Bolan, N., & Cornejo, P. (2012). Phytoremediation of metal-polluted soils by arbuscular mycorrhizal fungi. Critical Reviews in Environmental Science and Technology, 42(7), 741-775. https://doi.org/10.1080/10643389.2010.528518
39. Montalto, M., Maggiano, N., Ricci, R., Curigliano, V., Santoro, L., Di Nicuolo, F., Vecchio, F. M., Gasbarrini, A., & Gasbarrini, G. (2004). Lactobacillus acidophilus protects tight junctions from aspirin damage in HT-29 cells. Digestion, 69(4), 225-228. https://doi.org/10.1159/000079152
40. Nawaz, A. H., Amoah, K., Leng, Q. Y., Zheng, J. H., Zhang, W. L., & Zhang, L. (2021). Poultry response to heat stress: its physiological, metabolic, and genetic implications on meat production and quality including strategies to improve broiler production in a warming world. Frontiers in Veterinary Science, 814. https://doi.org/10.3389/fvets.2021.699081
41. Nazifi, S. (1997). Hematological and Clinical Biochemistry of Birds. Shiraz University Press. 276 (In persian).
42. Ohno, A., Ano, T., & Shoda, M. (1995). Effect of temperature on production of lipopeptide antibiotics, iturin A and surfactin by a dual producer, Bacillus subtilis RB14, in solid-state fermentation. Journal of Fermentation and Bioengineering, 80(5), 517-519. https://doi.org/10.1016/0922-338X(96)80930-5
43. Olfati, A., Mojtahedin, A., Sadeghi, T., Akbari, M., & Martínez-Pastor, F. (2018). Comparison of growth performance and immune responses of broiler chicks reared under heat stress, cold stress and thermoneutral conditions. Spanish Journal of Agricultural Research, 16(2), e0505-e0505. https://doi.org/10.5424/sjar/2018162-12753
44. Placer, Z. A., Cushman, L. L., & Johnson, B. C. (1966). Estimation of product of lipid peroxidation (malonyl dialdehyde) in biochemical systems. Analytical Biochemistry, 16(2), 359-364. https://doi.org/10.1016/0003-2697(66)90167-9
45. Prvulovic, D., Kojic, D., Grubor-Lajsic, G., & Kosarcic, S. (2008). The effects of dietary inclusion of hydrated aluminosilicate on performance and biochemical parameters of broiler chickens. Turkish Journal of Veterinary & Animal Sciences, 32(3), 183-189.
46. Qi, X., Mu, X., Zhang, Z., Yu, J., Zhao, Q., Xu, H., & Gu, W. (2018). Effects of compound probiotics on immune function and mucosal structure of small intestine of broilers under stress. Chinese Veterinary Science/Zhongguo Shouyi Kexue, 48(10), 1332-1340.
47. Qureshi, S., Khan, H. M., Mir, M. S., Raja, T., Khan, A., Ali, H., & Adil, S. (2018). ffect of cold stress and various suitable remedies on performance of broiler chicken. The Journal of World's Poultry Research, 8(3), 66-73.
48. Rajapaksha, A. U., Ahmad, M., Vithanage, M., Kim, K.-R., Chang, J. Y., Lee, S. S., & Ok, Y. S. (2015). The role of biochar, natural iron oxides, and nanomaterials as soil amendments for immobilizing metals in shooting range soil. Environmental Geochemistry and Health, 37(6), 931-942. https://doi.org/10.1007/s10653-015-9694-z
49. Ranjbar, A., khatibjoo, A., & Karimi, K. (2013). Effect of Probiotic on Performance, Humoral Immunity, Gut Development and Ascites Incidence of Broiler Chickens Reared at Cold Environment. MSc thesis. University of Islamic Azad of Varamin, Iran (In Persian).
50. Rashidi, N., Khatibjoo, A., Taherpour, K., Akbari-Gharaei, M., & Shirzadi, H. (2020). Effects of licorice extract, probiotic, toxin binder and poultry litter biochar on performance, immune function, blood indices and liver histopathology of broilers exposed to aflatoxin-B1. Poultry Science, 99(11), 5896-5906. https://doi.org/10.1016/j.psj.2020.08.034
51. Regnier, J., & Kelley, K. (1981). Heat-and cold-stress suppresses in vivo and in vitro cellular immune responses of chickens. American Journal of Veterinary Research, 42(2), 294-299.
52. Safaeikatouli, M., Jafariahangari, Y., & Baharlouei, A. (2010). Effects of dietary inclusion of sodium bentonite on biochemical characteristics of blood serum in broiler chickens. International Journal of Agriculture and Biology, 12(6), 877-880.
53. Sahin, N., Onderci, M., Sahin, K., & Smith, M. O. (2003). Melatonin supplementation can ameliorate the detrimental effects of heat stress on performance and carcass traits of Japanese quail. Biological Trace Element Research, 96(1), 169-177. https://doi.org/10.1385/BTER:96:1-3:169
54. Salma, U., Miah, A., Maki, T., Nishimura, M., & Tsujii, H. (2007). Effect of dietary Rhodobacter capsulatus on cholesterol concentration and fatty acid composition in broiler meat. Poultry Science, 86(9), 1920-1926. https://doi.org/10.1093/ps/86.9.1920
55. Sanchez-Monedero, M., Cayuela, M. L., Roig, A., Jindo, K., Mondini, C., & Bolan, N. (2018). Role of biochar as an additive in organic waste composting. Bioresource Technology, 247, 1155-1164. https://doi.org/10.1016/j.biortech.2017.09.193
56. Saroeun, K., Preston, T., & Leng, R. (2018). Rice distillers’ byproduct and molasses-urea blocks containing biochar improved the growth performance of local Yellow cattle fed ensiled cassava roots, cassava foliage and rice straw. Bone, 3(3), 3.
57. SAS, I. (2004). SAS/WATTM User’s Guide. SAS Institute, Inc., Cary NC.
58. Siegel, H. (1995). Stress, strains and resistance. British Poultry Science, 36(1): 3-22. https://doi.org/10.1080/00071669508417748
59. Traffano‐Schiffo, M. V., Chuquizuta, T., Castro‐Giraldez, M., & Fito, P. J. (2021). Development of a methodology to categorize poultry meat affected by deep pectoral myopathy. Journal of Food Processing and Preservation, 45(3), e15226. https://doi.org/10.1111/jfpp.15226
60. Varmaghany, S., Torshizi, M. A. K., Rahimi, S., Lotfollahian, H., & Hassanzadeh, M. (2015). The effects of increasing levels of dietary garlic bulb on growth performance, systolic blood pressure, hematology, and ascites syndrome in broiler chickens. Poultry science, 94(8), 1812-1820.
61. Winders, T. M., Jolly-Breithaupt, M., Freeman, C., Mark, B., Erickson, G., & Watson, A. (2018). Evaluating the Effect of Feeding Biochar to Cattle on Methane Production and Diet Digestibility. 10th International Livestock Environment Symposium (ILES X),
62. Xu, S., Lin, Y., Zeng, D., Zhou, M., Zeng, Y., Wang, H., Zhou, Y., Zhu, H., Pan, K., & Jing, B. (2018). Bacillus licheniformis normalize the ileum microbiota of chickens infected with necrotic enteritis. Scientific Reports, 8(1), 1-10. https://doi.org/10.1038/s41598-018-20059-z
63. Yang, J., Zhang, M., & Zhou, Y. (2019). Effects of selenium-enriched Bacillus sp. compounds on growth performance, antioxidant status, and lipid parameters breast meat quality of Chinese Huainan partridge chicks in winter cold stress. Lipids in Health and Disease, 18(1), 1-10. https://doi.org/10.1186/s12944-019-1015-6
64. Zhou, H., Kong, L., Zhu, L., Hu, X., Busye, J., & Song, Z. (2021). Effects of cold stress on growth performance, serum biochemistry, intestinal barrier molecules, and adenosine monophosphate-activated protein kinase in broilers. Animal, 15(3), 100138. https://doi.org/10.1016/j.animal.2020.100138
65. Zhuang, H., Rothrock Jr, M. J., Line, J. E., Lawrence, K. C., Gamble, G. R., Bowker, B. C., & Keener, K. M. (2020). Optimization of in-package cold plasma treatment conditions for raw chicken breast meat with response surface methodology. Innovative Food Science & Emerging Technologies, 66, 102477. https://doi.org/10.1016/j.ifset.2020.102477